Useful life hacks to facilitate heavy cement mixing

Content

  • 1 Sand
  • 2 Water
  • 3 Lime
  • 4 Kneading process

Working with cement is not a simple process that requires certain skills. The knowledge of additional tricks will significantly facilitate the heavy mixing of cement. So, we will consider all methods in order.

/

Sand

Mandatory substance used for the preparation of cement mortar is sand. As a rule, most builders do not attach much importance to the amount of additive used, but in vain. The exact mass of sand used in the solution is quite important. The ideal is the proportion in which the volume of the substance exceeds the cement exactly three times.

/

Water

The amount of water should be approximately six liters for one cement bag. It is important to pay attention to the recommendations indicated by the manufacturer on the packaging.

/

Lime

Obtaining a more durable material will require an addition to the lime solution. The presence of this material means the need to increase the volume of water.

Kneading process

In order to prevent the filled material from remaining in large quantities on the walls, it is recommended to moisten the container with water before filling components. This will reduce waste and make it easier to mix.

instagram viewer

/

If a mechanical option is used, then falling asleep material should be done gradually. First, sand and cement are mixed into a homogeneous mass, and water is already added by the motor. This greatly facilitates the procedure, as it eliminates the possibility of lump formation.

/

The lack of a stirrer can compensate for the electric drill. Its use will require the entire procedure in the reverse order. First, water is poured, then the components are filled up.

/

I would like to pay attention to the main technical features of mixing, which can significantly facilitate the whole process:

  1. Kneading time should not exceed 15 minutes;
  2. The distance from the kneading point to the place of laying should not be more than 50 cm;
  3. The hand mixer is effective for a volume not exceeding 30 liters;
  4. The addition of crushed stone is best done by the simultaneous use of coarse and fine fractions;
  5. Manual kneading will be much easier when mixing solids, and only then adding water;
  6. Do not mix at low and minus temperatures. If there are no other options, then slightly warmed up water can simplify the procedure.
/

Manual cement mixing is not an easy task. However, the use of certain life hacks can significantly facilitate it while maintaining the maximum result.

  • When an adjustable floor is more profitable than a capital screedWhen an adjustable floor is more profitable than a capital screed
  • What mistakes are made when the radiator is connected diagonally?What mistakes are made when the radiator is connected diagonally?
  • What are the consequences of building a site without permission?What are the consequences of building a site without permission?
  • What errors lead to water hammer in the heating system and how to avoid themWhat errors lead to water hammer in the heating system and how to avoid them
  • Why does the grinder work, but the disk does not spinWhy does the grinder work, but the disk does not spin
  • What could cause the cabinet door to bendWhat could cause the cabinet door to bend
  • 5 reasons to change the wizard without waiting for the repair to finish5 reasons to change the wizard without waiting for the repair to finish
  • How to cut tiles without dustHow to cut tiles without dust
  • How to cut a fiberboard with a flat edge with a regular grinderHow to cut a fiberboard with a flat edge with a regular grinder
  • Why you should not put aluminum radiators on central heatingWhy you should not put aluminum radiators on central heating
  • Why you can not allow for flaws in the installation of roof nodes from corrugated boardWhy you can not allow for flaws in the installation of roof nodes from corrugated board
  • What boards can not be used for half-timberedWhat boards can not be used for half-timbered

New publications are published daily on our channel in Yandex. Zen

Go to Yandex. Zen/
Furniture in the nursery is definitely worth buying in bright colors.

Furniture in the nursery is definitely worth buying in bright colors.Helpful Hints

A closet is an indispensable thing in a home, especially for children. With its help, the child will keep order and put all the desired clothes on the right shelves. Furniture in the nursery is de...

Read More
Is it difficult to replace the laminate in the place of damage?

Is it difficult to replace the laminate in the place of damage?Helpful Hints

The restoration and repair of the laminate can hardly be called a simple matter, because it requires a very painstaking attitude. In the event that the coating is laid correctly, the maintenance t...

Read More
Computer tables can be not only direct.

Computer tables can be not only direct.Helpful Hints

Content 1 Dimensions 2 The form 3 Shelves 4 Stand 5 Materials of manufacture People working at home hardly need to explain the importance of competent design of the workplace. It should be erg...

Read More